Garage floor concrete in Orange TX - a floor that stays level under your truck
Garage floor cracked, sunk or holding water? We pack the ground evenly first, then pour a slab built to hold up.
- Service
- Garage floor concrete
- Call
- (409) 216-5078
How can you tell your garage floor needs to be redone?
Cracks that keep widening
A crack that started as a hairline and now catches your shoe usually means the ground under that part of the floor has moved. The longer it runs, the more water gets under the slab and the more of the floor ends up coming out.
One side sitting lower
When a corner or the strip by the door has dropped below the rest, the dirt under it has usually settled or washed out. If you wait, that edge tends to break off, and it can start catching the garage door or your tires.
Water standing on the floor
Puddles that sit after a rain or after you wash the car mean the floor has tipped the wrong way or sunk in the middle. That water finds the cracks and keeps softening the ground underneath, so a small repair turns into a full replacement.
What goes into a new concrete garage floor?
Garage floor concrete in Orange, TX means a new slab poured on ground we've packed evenly, then finished and given time to cure, so you end up with a floor built to resist settling and cracking under your car and your tools.
Most people call because the old floor has cracked, sunk or started holding water, and they want to know whether it can be saved or has to come out. If part of it can stay, concrete cutting takes the bad section out cleanly. The price moves with the size of the garage, whether we're breaking out an old slab, how thick the floor needs to be for what you park on it and whether you want a coating later. The schedule turns on the permit, the weather on pour day and the wait while the concrete cures. Your written estimate spells out what's included and what isn't, so you know what you're paying for before we start.
Details to note before an estimate
- Garage size in square feet
- Whether the old slab comes out
- Heaviest vehicle or equipment parked inside
- Any coating you plan to add later
How we do garage floor concrete, start to finish
If there's an old floor, we break it out and haul it off, then get down to the subgrade, the dirt the slab actually sits on, and compact it evenly across the whole garage, because that ground work matters more than anything else on a garage floor. It's also the part you never see again and the first thing people want to cut when the budget gets tight, and I'd rather you spend less on the finish than skimp underneath. If you park a truck, a boat or heavy equipment in there, we plan a thicker slab instead of leaning on wire mesh, since mesh mostly holds the edges of a crack together after it happens rather than making the floor stronger. We set the forms so the floor falls toward the door and not toward the house, pour early before the afternoon heat can leave a weak, dusty top, and finish it smooth or with a light broom texture so tires and boots grip. Then we cut control joints, shallow grooves that give the slab a straight line to crack along instead of a random one, and cover the fresh concrete with waterproof sheets, wet burlap or a curing compound so it keeps its water long enough to cure and gain strength, taking extra care when it's very hot or cold. If you want a coating, we plan it for after the slab has dried out, not right behind the finishers, because concrete can look dry long before it is and a coating put on too early lets go. Satisfaction guaranteed on every job.
A garage floor rarely sits by itself. Some owners want color, stain or a pattern on it, and that's decorative concrete, which we plan alongside the slab from the start. If your garage sits at the bottom of a slope or the dirt beside the driveway keeps washing toward the door, a short concrete retaining wall holds that ground back so it stops ending up on your new floor.
Other work that often goes with a garage floor
Decorative concrete
If plain gray isn't what you want, color, stain or a patterned surface gives the garage floor a finished look that's easy to sweep.
Concrete retaining walls
When a slope crowds the garage or runoff carries mud to the door, a wall holds the dirt in place so it stays off the driveway.
What happens after you call about a garage floor in Orange?
Call and I come out
Call (409) 216-5078 or send the form, and I'll come out to measure the garage, ask what you park in it and look at what's sitting under the old floor. If something comes up that I can't answer standing there, I'll tell you and go find out.
Get it all in writing
You get a written estimate that spells out what's included and what isn't, from removing the old slab to how thick we're pouring. Before any forms go up, we find out which city, county or parish office covers your address and handle the permit with them if the job needs one.
Our crew pours and finishes
Our crew lead runs the job on site, and our finishers prep the ground, set forms, pour and finish the slab. When it's done, I walk the floor with you and go over how long to wait before you drive on it.
Questions before you pour a garage floor
How much does a concrete garage floor cost near Orange, TX?
A concrete slab in the Beaumont area usually runs about $6 to $11 per square foot, before any staining or stamping. That's the going rate around here, not our price, and if an old floor has to be broken out first, that cost gets added on top of the new slab. Your own figure comes from the written estimate after I've measured and seen what's underneath.
How long does a new garage floor take before I can park on it?
You should be able to walk on new concrete within about 48 hours, and waiting a week before you park a car or set anything heavy on it is the safe choice. It keeps curing for about a month, so go easy with heavy equipment in those first weeks. Plan on walking in first and driving in later.
What causes a garage floor to crack?
Most garage floors crack because the ground under them wasn't packed evenly, so part of it settles and the slab breaks over the low spot. When that happens, it doesn't much matter how thick or strong the concrete was, which is why the ground work counts for more than anything else on this job. Cracks also wander into odd places when nobody cut joints to guide them.
Do I need a permit for a garage floor in Orange, TX?
Inside Orange city limits, the City of Orange Building Inspections Department issues permits for building construction, so they're the ones who decide what your floor needs. The city's building permit application can be sent to permits@orangetexas.gov. We're licensed and fully insured, and we handle the permit side with the city when the job calls for one.
Do I need an elevation certificate to pour a garage floor in a flood zone in Orange?
Yes, if your lot is in a special flood hazard area, because the City of Orange requires an elevation certificate for all work there. Whether your lot falls inside one is something we look at for your address at the site visit, so it's sorted out before we schedule the pour.
Do I need a soil test before pouring a garage floor?
You need a soil engineer's advice most when the slab goes on fill, on soil that shrinks and swells, or on ground that's been regraded lately. Fill brought in over the last several years may still be settling, so I'll ask what's under your garage at the estimate and tell you if I think it needs a closer look. If you're outside the city limits and the job needs fill or grading, Orange County lists that work among what needs a county Development Permit, and you can check on the county's development and floodplain page.
Get a written estimate for your garage floor
Send the form and we'll get back to you within one business day to set a time for me to come out. The estimate is free and done on site, with no obligation. I'll measure, look the floor over and put what's included in writing so you can decide on your own time.
Explore our services and areas
Services
- Concrete driveway building
- Concrete patio construction
- Stamped concrete services
- Concrete sidewalk building
- Decorative concrete
- Concrete retaining walls
- Concrete floor installation
- Concrete pool decks
- Concrete steps construction
- Slab foundation building
- Foundation installation
- Concrete parking lot building
- Concrete footings
- Foundation raising
- Concrete cutting
Book a look at your garage floor
Orange Concrete Company works both sides of the state line, so call (409) 216-5078 with your garage size handy and whether the old slab comes out.