Concrete floor installation in Orange TX - a level, dry slab ready for your flooring
Floor cracked, damp or out of level, or building new? We pour a flat, well-prepped slab that's ready for the covering you want.
- Service
- Concrete floor installation
- Call
- (409) 216-5078
How can you tell a concrete floor needs replacing?
Cracks that keep opening up
A crack that keeps getting wider, or has one side sitting higher than the other, usually means the ground under the slab has moved. Left alone, it catches toes, breaks any tile laid over it and gives water a way in.
Damp spots or loose flooring
Dark patches, a musty smell, or tile and vinyl coming loose often mean moisture is wicking up through a slab with no vapor barrier or a torn one. Each new covering you put down tends to fail the same way, so you end up paying for the floor twice.
A floor that dips or rocks
If furniture rocks, a level shows a low spot or water collects in one corner, the base under the slab probably settled because it was raked flat instead of packed. The dip usually keeps growing, and cracks tend to follow its edge.
What goes into a new concrete floor in Orange, TX?
Concrete floor installation in Orange, TX starts under the slab. We dig out and pack the ground it sits on, lay a vapor barrier film to keep ground moisture out of your flooring, and pour a flat slab ready for tile, wood, carpet or a coating.
A lot of floor calls come from people adding a room, a shop or a storage building, or tearing out an old slab that cracked, sank or kept sweating through the tile. The price mostly turns on the square footage, whether old concrete has to come out, how much digging and fill the ground needs, the slab's thickness and steel, and what goes on top, while the schedule turns on the permit, the ground prep and the cure time before flooring can go down. If it's a garage, our garage floor concrete page covers that job, and either way I put your own number in writing at the estimate, with what's included.
Details to note before an estimate
- Rough size in square feet
- Planned flooring, coating or bare concrete
- Old slab to remove, or bare ground
- How the room will be used
How we handle concrete floor installation
I start by asking what's going on top of the floor and what's under it now, because tile, wood and a coating all handle moisture differently. Our crew digs out the subgrade, the dirt the slab sits on, and packs it firm instead of raking it level, since a raked base settles and takes the floor down with it. Before the vapor barrier goes in, we clear out rocks, roots and anything sharp, because that film is the part people forget and even a small hole can let a lot more moisture up into your flooring, so I'll also talk with you about exactly where it sits. Then we set rebar, the steel that holds the slab together once it cracks, pour early in the day so the top doesn't come out weak and dusty, and cut control joints, shallow saw lines that give the concrete a planned place to crack, on time instead of days later. If the budget gets tight, I'd rather spend it under the slab than on top, because you can redo a finish later but you can't fix a bad base without tearing out the floor.
A new floor is often one piece of a bigger job. If the room opens toward a pool, we can pour concrete pool decks that tie into the same grade, and if the floor sits up off the ground, concrete steps give you a solid way in and out.
Work that often goes with a new floor
Concrete pool decks
If the new room opens toward the pool, a deck that drains away from the house keeps water off your floor and gives bare feet grip.
Concrete steps construction
When the finished floor sits higher than the ground outside, poured steps at the door give you a solid, even climb that stays put underfoot.
What happens after you call about a concrete floor in Orange?
Call or send the form
Call (409) 216-5078 or send the form, and I'll set a time to come look at the site. We're based in Orange and work the cities around it on both sides of the state line, from Beaumont and Port Arthur over to Lake Charles and Sulphur.
I measure and look underneath
I measure, ask what the floor is for and look at what's under it now, whether that's an old slab or bare dirt. You get a written estimate that spells out what's included and what isn't, so there's no guessing about what you're paying for.
We sort out the permit
Before any forms go up, we find out whether your address falls under the city or the county. We handle the permit side with that office when the job calls for one.
Our crew pours and finishes
Our crew lead runs the job and our finishers prep the ground, set forms, pour and finish, with inspections called in to the city and the work kept inside its noise rules. When it's done I walk the floor with you, and it's satisfaction guaranteed on every job.
Questions before you book a concrete floor
How much does a concrete floor cost near Orange, TX?
Concrete slab installation in nearby Beaumont usually costs about $6 to $11 per square foot before any staining or stamping, and that's the going rate in the area, not our price. In that same cost guide, reinforced slabs reach a higher top price than unreinforced pads, and old concrete to haul off or extra fill pushes a job up too. I measure on site and put our number in writing.
Do I need a permit to pour a concrete floor in Orange, TX?
Inside city limits, Orange requires permits for all building construction, and contractors get them from the Building Inspections Department before work begins. To get that permit, a contractor provides a valid driver's license and a $10,000 surety bond issued to the city, so it's fair to ask anyone bidding your floor whether they hold one. We're licensed and fully insured.
Will my new concrete floor crack?
It will probably get a few small cracks, and that's normal for concrete. The concrete industry's floor guide says some random cracking should always be expected, even with saw-cut joints spaced close together, and that steel won't stop cracks but properly sized and placed steel should keep them tightly closed. I'd rather tell you that up front than promise a floor that never cracks.
How long does a new concrete floor take to cure before I can use it?
You can usually walk on a new concrete floor within 48 hours, but it takes a month to fully cure, which is the slow hardening that gives concrete its strength. To be safe, plan on waiting a week before heavier loads like shelving or equipment go on it.
What is the best way to protect flooring over a new concrete slab?
The same floor guide says a vapor barrier placed in direct contact with the slab gives floor coverings and coatings the most protection. It also says the plain polyethylene sheeting used in the past shouldn't be considered for moisture protection under a slab. If you're planning tile, wood or a coating, ask each bidder where their barrier goes and what it's made of.
Do I need a flood certificate or county permit for a concrete slab near Orange?
If the site is in a special flood hazard area, zone A or V, the city's new construction page lists an Elevation Certificate for the work. Outside the city, Orange County requires a Development Permit for any new building or any improvement over 50% of the building's value, and its development and floodplain page says any building with living quarters needs an inspection at the foundation stage, before concrete is placed. If you know your flood zone, mention it when you call.
Get your concrete floor measured and priced in writing
Send the form and we'll get back to you within one business day to set a time for me to come out. The estimate is free, done on site and comes with no obligation, and you get what's included in writing.
Explore our services and areas
Services
- Concrete driveway building
- Concrete patio construction
- Stamped concrete services
- Concrete sidewalk building
- Garage floor concrete
- Decorative concrete
- Concrete retaining walls
- Concrete pool decks
- Concrete steps construction
- Slab foundation building
- Foundation installation
- Concrete parking lot building
- Concrete footings
- Foundation raising
- Concrete cutting
Get your concrete floor on the schedule
Call (409) 216-5078 any day until 10 PM or send the form, and have your square footage and planned flooring handy so I can come ready.