Concrete Contractor in Sulphur, LA - Driveways and Slabs Built on Solid Ground
Orange Concrete Company pours driveways, patios, slabs and foundations for homes and businesses in Sulphur, LA. We're based in Orange, TX, and we start each job by checking the ground and the water before anything gets poured.
- Service area
- Sulphur, LA
- Call
- (409) 216-5078
Homes, shops and yards across Sulphur
Sulphur is a short run east of us on I-10, and the calls we get there usually come from homeowners with a driveway that's sunk, a patio that holds water or a slab that's cracked clean through. Builders and small business owners call too, mostly to have a site looked at before anything gets poured.
We do the same work next door in Lake Charles and down in Prien, and back on the Texas side in cities like Port Neches. Older brick houses sit near newer subdivisions here, and in both the trouble usually starts under the concrete, not on top of it. Yards that stay wet after a hard rain are common, so on a Sulphur job I spend more of the visit on how firm the dirt is than on the finish, because that decides how deep we dig and how much base goes back in.
Our services in Sulphur, LA
Sulphur driveways carry trucks, and the ones we replace have usually sunk at the edges or split down the middle. We break it out, rebuild the ground and pour with rebar, steel that keeps cracks closed.
Patios here catch hard rain off the roof, and one that slopes toward the house sends it to your foundation. We check where water runs first and pitch the slab away from the walls.
Shops and garages around Sulphur need a floor that stays flat under weight, so our concrete floor installation starts with the dirt. We pack the base and cut control joints, grooves that pick where cracks go.
A slab foundation carries the whole house, so for new homes in Sulphur I look hard at the site before we pour. We dig out soft spots and set the steel the plans call for.
When a Sulphur house starts showing cracked brick or doors that stick, the slab underneath has usually settled on one side. We find where it dropped and why, then bring the house back up.
Older Sulphur slabs often need a section cut out for a new drain line, a door or repair, without breaking up the rest. We saw clean lines so the patch ties into concrete that's still sound.
Every service we offer
Concrete driveway building
Concrete patio construction
Stamped concrete services
Concrete sidewalk building
Garage floor concrete
Decorative concrete
Concrete retaining walls
Concrete floor installation
Concrete pool decks
Concrete steps construction
Slab foundation building
Foundation installation
Concrete parking lot building
Concrete footings
Foundation raising
Concrete cutting
What happens when you call us about a Sulphur job
Call us or send the form
Call (409) 216-5078 or send the form and tell us what you've got, whether that's a sunken driveway, a new patio or a house that needs to come up. We set a time for me to come out, and it helps if you're home, because I'll have questions about the yard.
I look, measure and ask
I measure, ask what the slab has to carry and look at what's under it and where the water runs. You get a written estimate that spells out what's in it and what isn't, and we find out whether your address falls under the city or the parish before any forms go up.
Our crew preps and pours
Our crew lead runs the job while the crew digs out, packs the base and sets forms and steel, then our finishers pour and finish it, early in the day when it's hot so the top doesn't come out weak and dusty. Rain and any permit wait move the start date more than the pour itself does.
I walk the job with you
When it's done I walk it with you and tell you when you can walk on it and when the car can go back, because the slab is still curing, gaining strength as it hardens. Driving on it early is how a good slab gets cracked.
Sulphur concrete questions answered
Does concrete work in Sulphur, LA have to be inspected?
Yes, the City of Sulphur requires all construction work inside its limits to be inspected. The city's inspections and permits office handles building and residential inspections, so that's who to ask whether your driveway or slab also needs a permit.
How do I apply for a building permit in Sulphur, LA?
You can apply for building permits and specialty trade permits online through the city, start to finish. When your concrete job calls for one, we handle the permit side with the city, so you don't have to learn the system for one driveway.
Can a contractor start work before the permit is issued in Louisiana?
No, Louisiana law makes it a violation for a contractor to begin work without a permit or before the permit is issued. The same state laws cover contractors who misstate a job's value or scope or skip required inspections, they apply in every parish, and the state contractors' licensing board enforces them. We're licensed and fully insured, and on a job that needs a permit we wait for it before we start.
How much does a new concrete driveway cost in Sulphur, LA?
Most of the price comes from the size, the thickness and how much ground work your yard needs before we pour. Tearing out and hauling off an old slab, adding rebar or going with a stamped or colored surface all add to it, and the written estimate lists each piece. If the budget's tight, cut the fancy finish, not the base, because a plain broom finish, the light texture that gives shoes and tires some grip, holds up on packed ground and a pretty surface on soft dirt cracks anyway.
What causes a concrete driveway to sink in Sulphur, LA?
A driveway usually sinks because it was poured on dirt raked level instead of dug out and packed, so the concrete settled right along with the ground. Water speeds it up when it pools at the edges after a hard rain and softens what's underneath.
Will a new driveway in Sulphur crack like my old one?
It usually won't crack the way the old one did if it sits on packed ground and its control joints are cut on time, because any crack that forms will follow a joint where you'll barely see it. Concrete still shrinks as it cures, so I can't promise you'll never see a hairline, but the rebar inside keeps one from opening up or lifting into a trip edge.
Get a free on-site concrete estimate in Sulphur
Send the form and we'll get back to you within one business day to set a time for me to come out to your place in Sulphur. The estimate is free, done on site and comes with no obligation, and I'll put what's included in writing.
- Call
- (409) 216-5078
- Location
- Orange, TX 77630
- Hours
- Mon–Fri: 6 AM–10 PM, Sat–Sun: 8 AM–10 PM
Tell us about your Sulphur concrete job
Call (409) 216-5078 or send the form, and if your job turns up a question I can't answer on the spot, I'll go find out instead of guessing.